Wikipedia

Dresden Generating Station

(Redirected from Dresden-1)

Dresden Generating Station (also known as Dresden Nuclear Power Plant or Dresden Nuclear Power Station) is the first privately financed nuclear power plant built in the United States. Dresden 1 was activated in 1960 and retired in 1978. Operating since 1970 are Dresden units 2 and 3, two General Electric BWR-3 boiling water reactors. Dresden Station is located on a 953-acre (386 ha) site in Grundy County, Illinois near the city of Morris. It is at the head of the Illinois River, where the Des Plaines River and Kankakee River meet. It is immediately northeast of the Morris Operation—the only de facto high-level radioactive waste storage site in the United States. It serves Chicago and the northern quarter of the state of Illinois, capable of producing 867 megawatts of electricity from each of its two reactors, enough to power over one million average American homes.

Dresden Generating Station
Exterior view of Dresden Station circa 1971
Map
CountryUnited States
LocationGoose Lake Township, Grundy County, near Morris, Illinois
Coordinates41°23′23″N 88°16′5″W / 41.38972°N 88.26806°W / 41.38972; -88.26806
StatusOperational
Construction beganUnit 1: May 1, 1956
Unit 2: January 10, 1966
Unit 3: October 14, 1966
Commission dateUnit 1: July 4, 1960
Unit 2: June 9, 1970
Unit 3: November 16, 1971
Decommission dateUnit 1: October 31, 1978
Construction costUnit 1: $423 million (2010 USD) or $577 million in 2023 dollars[1]
Unit 2: $856 million (2010 USD) or $1.17 billion in 2023 dollars[1]
Unit 3: $828 million (2010 USD) or $1.13 billion in 2023 dollars[1]
OwnerConstellation Energy
OperatorConstellation Energy
Nuclear power station
Reactor typeBWR
Reactor supplierGeneral Electric
Cooling towers4 × Mechanical Draft
(supplemental only)
Cooling sourceDirect open-cycle mode:[a]
Closed-cycle mode:[b]
Indirect open-cycle mode:[c]
Thermal capacity1 × 700 MWth (decommissioned)
2 × 2957 MWth
Power generation
Units operational1 × 902 MW
1 × 895 MW
Make and modelUnit 1: BWR-1 (Mark 1)
Units 2–3: BWR-3 (Mark 1)
Units decommissioned1 × 197 MW
Nameplate capacity1797 MW
Capacity factor98.13% (2017)
73.30% (lifetime, excluding Unit 1)
Annual net output15,447 GWh (2017)
External links
WebsiteDresden Generating Station
CommonsRelated media on Commons
[edit on Wikidata]
Control room of Dresden Station circa 1962

In 2004, the Nuclear Regulatory Commission (NRC) renewed the operating licenses for both reactors, extending them from forty years to sixty.[2]

Unit 1

edit
 
Inside the Dresden 1 nuclear power plant

After the Atomic Energy Act of 1954 allowed private companies to own and operate nuclear facilities, Commonwealth Edison contracted with General Electric to design, construct, and place into operation the 192 MWe Dresden Unit 1 for $45M in 1955.[3] One-third of the contract price was shared by a consortium of eight companies comprising the Nuclear Power Group Inc.

The BWR at GE's Vallecitos Nuclear Center and the AEC's BORAX experiments provided research data and operator training for Dresden.

The core contained 488 fuel subassemblies, 80 control rods, and 8 instrument nozzles. Each subassembly contained 36 fuel rods in a Zircaloy-2 channel. The fuel was uranium dioxide clad in Zircaloy-2 tube. The core thermal power was 626 MWt. The reactor vessel was rated to 1015 psia and measured 12 feet 2 inches (3.71 m) diameter and 42 feet (13 m) tall.

 
Dresden 1 Nuclear Flow Diagram featured a secondary steam generator for load following

The reactor featured a dual cycle, with steam coming from both the stream drum and steam generators. This made for rapid response to changes in power demand. Reactor power was regulated by actuation of the secondary admission valve by the turbine's governor. Decreasing the rate of secondary steam reduces reactor power, and vice versa. Thus, the secondary pressure varies with the external load.

Cooling

edit

The plant has three cooling modes:

  • Direct open-cycle mode:[d] Intake from canal leading to the Kankakee River,[e] discharge directly to the Illinois River. The cooling canal system, cooling lake, and the supplementary cooling towers are completely bypassed in this mode of operation.
  • Indirect open-cycle mode:[f] Intake from canal leading to the Kankakee River,[e][g] discharge to cooling canal leading to Dresden Cooling Lake,[h] discharged from lake through return cooling canal that eventually discharges into the Illinois River. Use of the cooling towers for supplemental cooling of canal system water is usually necessary during this mode of operation.
  • Closed-cycle mode:[i] Intake from return cooling canal leading back from Dresden Cooling Lake,[j] discharge to cooling canal leading to Dresden Cooling Lake.[h] Use of the cooling towers for supplemental cooling of canal system water is usually not necessary during this mode of operation.
 
Dresden Cooling Lake

It also has cooling towers[k][l]

Electricity Production

edit
Generation (MWh) of Dresden Generating Station[4]
Year Jan Feb Mar Apr May Jun Jul Aug Sep Oct Nov Dec Annual (Total)
2001 1,193,458 1,054,333 1,187,102 981,943 1,132,442 1,127,280 1,031,337 1,135,702 932,498 892,446 945,681 924,451 12,538,673
2002 1,234,842 1,108,990 1,059,816 1,186,361 1,210,951 1,176,948 1,133,199 1,210,328 1,097,968 797,663 1,223,682 1,145,176 13,585,924
2003 1,246,460 1,160,493 1,250,523 1,242,216 1,212,105 1,058,939 1,293,159 1,291,997 1,230,004 847,958 941,888 901,425 13,677,167
2004 1,216,081 1,157,391 1,286,564 1,113,658 954,565 1,250,516 1,294,621 1,075,250 1,006,250 1,131,669 1,176 858,976 12,346,717
2005 1,296,266 1,149,577 1,203,983 1,153,170 1,211,033 1,220,520 1,288,247 1,227,178 943,039 1,264,403 373,412 1,291,625 13,622,453
2006 1,295,498 1,164,240 1,292,561 1,248,987 1,281,759 1,245,263 1,232,623 1,284,318 1,246,890 1,290,115 568,728 1,291,064 14,442,046
2007 1,294,287 1,163,545 1,293,573 1,253,535 1,199,725 1,248,937 1,291,916 1,281,698 1,202,803 1,228,109 783,991 1,288,662 14,530,781
2008 1,085,546 1,211,845 1,289,661 1,252,854 1,292,759 1,248,659 1,291,802 1,283,863 1,092,984 1,208,852 832,043 1,293,977 14,384,845
2009 1,297,183 1,161,648 1,283,016 1,186,675 1,282,268 1,246,218 1,289,811 1,286,199 1,242,479 1,201,845 578,552 1,211,519 14,267,413
2010 1,307,507 1,180,006 1,301,495 1,254,920 1,282,526 1,248,695 1,283,631 1,282,172 1,248,247 1,185,775 712,494 1,305,655 14,593,123
2011 1,311,449 1,174,027 1,306,344 1,262,166 1,279,032 1,248,876 1,258,176 1,278,908 1,244,684 971,176 1,041,964 1,337,521 14,714,323
2012 1,346,736 1,251,071 1,320,626 1,281,096 1,297,546 1,265,316 1,259,150 1,265,070 1,140,079 1,262,012 862,794 1,250,504 14,802,000
2013 1,385,187 1,256,336 1,383,409 1,330,425 1,342,703 1,311,561 1,353,411 1,347,863 1,309,659 1,166,351 866,361 1,359,206 15,412,472
2014 1,372,469 1,258,105 1,384,760 965,983 1,265,939 1,314,171 1,359,344 1,353,622 1,296,753 1,237,769 936,656 1,383,369 15,128,940
2015 1,302,562 1,099,619 1,377,180 1,323,646 1,334,905 1,304,534 1,361,087 1,355,055 1,310,891 1,316,146 872,051 1,230,682 15,188,358
2016 1,392,370 1,295,151 1,360,106 1,320,647 1,329,951 1,299,800 1,350,994 1,328,256 1,240,328 1,185,785 969,514 1,370,991 15,443,893
2017 1,390,462 1,246,232 1,379,854 1,317,074 1,351,025 1,308,476 1,351,499 1,355,759 1,229,144 1,195,284 943,489 1,376,584 15,444,882
2018 1,395,679 1,255,218 1,374,523 1,329,334 1,336,410 1,281,471 1,337,561 1,343,205 1,275,664 1,190,411 1,057,082 1,361,577 15,538,135
2019 1,372,972 1,263,033 1,382,807 1,328,485 1,225,938 1,316,784 1,346,740 1,333,857 1,138,813 1,135,829 1,002,013 1,234,444 15,081,715
2020 1,284,207 1,302,119 1,380,077 1,299,281 1,348,037 1,304,960 1,339,834 1,236,024 1,290,826 1,139,730 1,170,837 1,382,956 15,478,888
2021 1,391,356 1,260,404 1,374,530 1,319,595 1,148,772 1,301,750 1,353,735 1,340,707 1,301,614 909,872 870,624 1,383,721 14,956,680
2022 1,394,155 1,257,900 1,375,753 1,256,880 1,343,351 1,292,553 1,289,656 1,344,736 1,299,094 1,251,188 920,098 1,383,586 15,408,950
2023 1,384,921 1,247,143 1,357,294 1,157,187 1,333,924 1,300,289 1,338,236 1,341,796 1,276,309 1,198,281 962,559 1,371,259 15,803,198
2024 1,384,689 1,284,436 1,338,397 1,310,136 1,322,304 1,287,859 1,339,367 1,233,133 --

Incidents

edit

Between the 1970s and 1996, Dresden was fined $1.6 million for 25 incidents.

  • June 5, 1970: A false high pressure signal due to instrument failure on the Dresden II reactor pressure control system caused turbine valves to dump steam (a "turbine trip"), which in turn automatically initiated a SCRAM. Void collapse in the reactor water caused the reactor water level to drop, which resulted in an automatic increase in feedwater flow. The feedwater pumps then tripped on low suction pressure. One pump turned back on automatically when the low suction pressure signal reset, feeding water rapidly into the now lower-pressure reactor vessel. Water level in the reactor rose rapidly until water entered the main steam lines. At this point, the false high pressure signal disappeared. The turbine dump valves closed, increasing back pressure in the reactor vessel and slowing the feedwater inlet flow. Cooling reactor water temperature caused further void collapse. Reactor water level began to rapidly lower once again. This again automatically caused the feedwater system to increase the flow rate into the vessel, and began to raise reactor water level. As cooler feedwater was again rapidly pumped into the reactor, void collapse caused water level to lower. The feedwater system responded by increasing feedwater flow. However, the indicator needle on the water level recorder stuck, which caused the operator to assume level had stopped rising in the reactor. The operator began increasing feedwater flow in order to raise water level in the reactor, manually overriding the automatic control system. The operator never checked a second indicator that showed the increasing level. Reactor water level continued rising and flooded the main steam lines. Two minutes later, the operator tapped on the water level recorder and the water level needle became unstuck, at which point the operator began reacting to the now high water level by manually reducing feedwater flow. At this point, the operator manually opened a steam line relief valve to reduce rising reactor pressure. However, due to the earlier introduction of water into the main steam lines, a hydrostatic shock occurred in the steam lines, which caused a safety valve to open, admitting steam and water into the drywell causing drywell pressure to increase. This caused the initiation of safety injection systems, and for the next 30 minutes reactor water level and pressure seesawed as the operators attempted to stabilize the reactor. It was not until two hours later that reactor level, reactor pressure and drywell pressure were reduced to normal.[5] The movie The China Syndrome bases its initial plot device on this event, with the needle becoming unstuck when the operator taps the recorder.[6]
  • December 8, 1971: Events similar to the ones the year earlier on Dresden II occur on Dresden III.[5]
  • May 15, 1996: Lowering water levels around the nuclear fuel in unit 3[7] reactor's core prompt a shut down at Dresden Generating Station and placement on the NRC's "watch list" that merit closer scrutiny by regulators. Dresden was on the NRC watch list six out of nine years between 1987 and 1996, longer than any of the 70 other operating plants in the nation.[8]
  • July 15, 2011: Plant declared an Alert at 10:16 a.m after a chemical leak of sodium hypochlorite restricted access to a vital area that houses plant cooling water pumps.[9]

Surrounding population

edit

The Nuclear Regulatory Commission defines two emergency planning zones around nuclear power plants: a plume exposure pathway zone with a radius of 10 miles (16 km), concerned primarily with exposure to, and inhalation of, airborne radioactive contamination, and an ingestion pathway zone of about 50 miles (80 km), concerned primarily with ingestion of food and liquid contaminated by radioactivity.[10]

The 2010 U.S. population within 10 miles (16 km) of Dresden was 83,049, an increase of 47.6 percent in a decade, according to an analysis of U.S. Census data for msnbc.com. The 2010 U.S. population within 50 miles (80 km) was 7,305,482, an increase of 3.5 percent since 2000. Cities within 50 miles include Chicago (43 miles to city center).[11]

Ownership

edit

Both currently operating units are owned and operated by Constellation Energy following separation from Exelon, which also owns and is responsible for the decommissioning of Unit 1. Prior to August 3, 2000, all three units were owned by Commonwealth Edison.[12][13]

Seismic risk

edit

The Nuclear Regulatory Commission's estimate of the risk each year of an earthquake intense enough to cause core damage to the reactor at Dresden was 1 in 52,632, according to an NRC study published in August 2010.[14][15]

Averted closure

edit

In August 2020, Exelon announced they would close the plant in November 2021 for economic reasons, despite the plant having licenses to operate for about another 10 years and the ability to renew the licenses for an additional 20 years beyond that. On September 13, 2021, the Illinois state senate passed a bill subsidizing the Byron and Dresden nuclear plants,[16] which Governor J. B. Pritzker signed into law on September 15,[17] and Exelon announced it would refuel the plants.[18]

Notes

edit
  1. ^ Currently only allowed when both units are out of service, rarely used.
  2. ^ Used from October 1 through June 14.
  3. ^ Used from June 15 through September 30, or approximately 8.5 months of the year.
  4. ^ Currently only allowed when both units are out of service, rarely used.
  5. ^ a b c During periods of low river flow, intake water may also be indirectly drawn from the Des Plaines River.
  6. ^ Used from June 15 through September 30, or approximately 8.5 months of the year.
  7. ^ Up to 940,000 US gallons per minute (59 m3/s) is withdrawn from the river by six pumps each rated at 157,000 US gallons per minute (9.9 m3/s)).
  8. ^ a b Water is pumped from the cooling canal into the 1,275 acres (516 ha) cooling lake via a lift station with 6 × 167,000 US gallons per minute (10.5 m3/s) pumps. The cooling lake has 5 zones through which the water slowly travels over the course of 2.5 days before it exits the cooling lake.
  9. ^ Used from October 1 through June 14.
  10. ^ Limited amounts (up to 70,000 US gallons per minute (4.4 m3/s)) of makeup water is drawn from the Kankakee River as needed,[e] and limited discharge (up to 50,000 US gallons per minute (3.2 m3/s)) to the Illinois River happens in order to minimize dissolved solids concentrations in the cooling canals/lake.
  11. ^ Prior to 2000, supplemental cooling was provided via spray canals (spray systems installed in both the hot and cold (return) cooling canals) rather than the current cooling towers.
  12. ^ 1 × 12-cell tower (single-wide, built between 2000 and 2001), 2 × 18-cell towers (double-wide, built in 2000), and 1 × 6-cell tower (single-wide, built between 2003 and 2004) with an overall total of 54 cells. The 12-cell tower is only used for supplementary cooling of the cold (return) cooling canal as necessary in order to maintain discharge water temperatures within permitted levels, while the three other cooling towers are used for the supplementary cooling of water in the hot cooling canal. The three hot canal cooling towers are fed by 7 pumps rated at 135,067 US gallons per minute (8.5214 m3/s) each (total flow of 735,469 US gallons per minute (46.4009 m3/s)). The single 12-cell cold (return) canal cooling tower is fed by 24 pumps rated at 8,800 US gallons per minute (0.56 m3/s) each (total flow of 211,200 US gallons per minute (13.32 m3/s)). The 6-cell tower was added to provide additional cooling for the extended power uprates (+17%) on Units 2 & 3 that Exelon requested in December 2000, which were approved by the NRC in December 2001, although it was not until the end of 2002 that the uprates were implemented at both units (the units were also not operated at the uprated power for most of 2003 due to steam dryer cracking problems), and this additional cooling tower meant to provide additional cooling capacity to accommodate the additional thermal output from the outrate was not added until sometime between 2003 and 2004.

References

edit
  1. ^ a b c Johnston, Louis; Williamson, Samuel H. (2023). "What Was the U.S. GDP Then?". MeasuringWorth. Retrieved November 30, 2023. United States Gross Domestic Product deflator figures follow the MeasuringWorth series.
  2. ^ "Dresden and Quad Cities, Nuclear Power Stations — License Renewal Application". U.S. Nuclear Regulatory Commission (NRC). February 13, 2007. Retrieved 2008-11-19.
  3. ^ "Power reactors". U.S. Atomic Energy Commission, Technical Information: 41–48. 1958-05-01. Retrieved 1 January 2020.
  4. ^ "Electricity Data Browser". www.eia.gov. Retrieved 2023-01-03.
  5. ^ a b 92nd CONGRESS. 22 March – 10 April 1972. This action was forbidden...
  6. ^ Ebert, Roger (1979-01-01). "The China Syndrome Movie Review (1979)". Roger Ebert. Retrieved 2013-12-30.
  7. ^ NRC dispatches special inspection team to Dresden Nuclear Plant to review reactor shutdown on May 15 (RIII-96-17) U.S. Nuclear Regulatory Commission (NRC). May 16, 1996. Retrieved 10 June 2016.
  8. ^ "Dresden Plant Placed On Nrc Watch List Again - tribunedigital-chicagotribune". Chicago Tribune. Archived from the original on 2015-09-29.
  9. ^ "NRC responds to alert to Dresden Nuclear Power Plant | FireDirect". Archived from the original on 2013-06-16. Retrieved 2013-05-05.
  10. ^ "NRC: Backgrounder on Emergency Preparedness at Nuclear Power Plants". Nrc.gov. Archived from the original on 2006-10-02. Retrieved 2012-08-17.
  11. ^ "Nuclear neighbors: Population rises near US reactors". NBC News. 2011-04-14. Retrieved 2024-08-16.
  12. ^ United States General Accounting Office (8 May 2004). NRC's Liability Insurance Requirements for Nuclear Power Plants Owned by Limited Liability Companies (PDF) (Report). United States General Accounting Office. p. 16. LCCN 2004398843. OCLC 56982748. GAO-04-654. Retrieved 29 April 2018.
  13. ^ Nuclear Regulatory Commission (31 August 2000). "Commonwealth Edison Company; Dresden Nuclear Power Station, Units 1, 2 and 3; Notice of Consideration of Approval of Application Regarding Proposed Corporate Restructuring and Opportunity for a Hearing". Federal Register. Office of the Federal Register. Retrieved 29 April 2018.
  14. ^ "What are the odds? US nuke plants ranked by quake risk". NBC News. 2011-03-16. Retrieved 2024-08-16.
  15. ^ "Archived copy" (PDF). Archived from the original (PDF) on 2017-05-25. Retrieved 2011-04-19.{{cite web}}: CS1 maint: archived copy as title (link)
  16. ^ Gardner, Timothy (2021-09-13). "Illinois approves $700 million in subsidies to Exelon, prevents nuclear plant closures". Reuters. Retrieved 2021-09-26.
  17. ^ "Gov. Pritzker Signs Transformative Legislation Establishing Illinois as a National Leader on Climate Action". Illinois.gov. Archived from the original on 2021-09-16. Retrieved September 26, 2021.
  18. ^ "Passage of Illinois Energy Legislation Preserves Nuclear Plants and Strengthens State's Clean Energy Leadership". www.exeloncorp.com. Retrieved 2021-09-26.
edit
Retrieved from "https://en.wikipedia.org/w/index.php?title=Dresden_Generating_Station&oldid=1255254390"