Wikipedia

DC-10 Air Tanker

(Redirected from Tamker 910)

The DC-10 Air Tanker is a series of American wide-body jet air tankers, which have been in service as an aerial firefighting unit since 2006.[1] The aircraft, operated by the joint technical venture 10 Tanker Air Carrier, are converted wide-body McDonnell Douglas DC-10-30 passenger jetliners, and are primarily used to fight wildfires, typically in rural areas. The turbofan-powered aircraft carry up to 9,400[2] US gallons (35,583 liters) of water or fire retardant in an exterior belly-mounted tank, the contents of which can be released in eight seconds. Four air tankers are currently in operation, all DC-10-30 aircraft, with the call-signs Tanker 910, 911, 912 and 914. The original Tanker 910, a DC-10-10, was retired in 2014.

DC-10 Air Tanker
Tanker 910 fighting the Rim Fire, August 2013
General information
TypeFirefighting aircraft
ManufacturerMcDonnell Douglas (conversion by 10 Tanker STC)
Primary user10 Tanker Air Carrier
Number built5 converted from former airliners
History
Introduction date2006
First flight2006
Developed fromMcDonnell Douglas DC-10

Development

edit
 
Tanker 912 taxiing in Albuquerque, New Mexico

10 Tanker Air Carrier, a New Mexico-based company, began researching the development of Next Generation airtankers in 2002. Company personnel were assembled with an extensive history of heavy jet operations, modifications and ownership. After two years of research into aerial firefighting requirements and future direction, 10 Tanker selected the DC-10 type for development. A Supplemental Type Certificate (STC) from the US Federal Aviation Administration (FAA) for modifications of DC-10 aircraft to be used for the aerial dispersant of liquids was issued in March 2006.[3] 10 Tanker then obtained a 14 CFR Part 137 Operating Certificate for aerial firefighting and Interagency Airtanker Board (IAB) approval for agency use.[4]

The first converted aircraft, a McDonnell Douglas DC-10-10 registered as N450AX, was originally delivered as a civil passenger plane to National Airlines in 1975, and subsequently flew for Pan Am, American Airlines, Hawaiian Airlines and Omni Air International.[5]

The conversion of the original airframe to a fire-fighting aircraft was a joint venture under the name of 10 Tanker Air Carrier between Cargo Conversions of San Carlos, California and Omni, with conversion work being performed by Victorville Aerospace at the Southern California Logistics Airport in Victorville, California.

Design

edit

The air tanker modification can be carried out to either a DC-10-10 or DC-10-30 series and involves the addition of an external tank and associated systems and support structure.[3]

The water or retardant is carried in three center-line belly tanks. The tanks have internal baffles to prevent fluid shift (and consequent shift in center of gravity) while in flight, and sit with a 15-inch (38 cm) ground clearance. All three tanks can be filled simultaneously on the ground in eight minutes. The retardant is gravity-fed out of the tanks, and the entire load can be dumped in eight seconds, although the actual drop rate is computer controlled by the flight crew in order to produce the desired retardant spread over the fire lines.[6] The aircraft is capable of applying a line of retardant 300 feet (91 m) wide by 1 mile (1.6 km) long.[7]

The external retardant tanks are designed to be filled from standard 3-inch (76 mm) cam-lock couplings. Utilizing one, two or three hoses, the tanks can be filled as quickly as base loading capabilities permit, typically 15–20 minutes. The tanks are vented to atmosphere by a vent system installed on top of each tank to allow sufficient air into and out of the tanks during retardant drops and filling. Accurate quantity gauges are part of the installation.[8]

The number of drops it can make in a day is only limited by the time it takes to reload the aircraft with water/fire retardant and fuel, as well as its need for a proper landing field, which may well be a considerable distance from the fire.[citation needed]

 
Tanker 912 next to Tanker 911 in February 2015

Skeptics have argued that the DC-10s lack maneuverability.[9] However, despite its size, field experience has proven the plane’s agility above all types of terrain and in all atmospheric conditions deemed suitable for fixed wing operations in a Fire Traffic Area (FTA).[10]

Unlike most existing and proposed Large Air Tankers (LATs), the DC-10 arrives at a Fire Traffic Area weighing significantly less than its certified maximum gross takeoff weight (MGTOW). This is principally due to the reduced fuel load carried on fire missions.[citation needed]

As a result:

  • The 10 is frequently dispatched at a takeoff weight 40% lighter than its certified MGTOW.
  • The 10 turns comfortably within the turn radius of smaller aircraft including Single Engine Air Tankers (SEAT) and lead planes.
  • The 10’s improved thrust to weight ratio significantly increases rate of climb, and greatly enhances safety margins in a failed engine scenario.
  • The 10 enjoys a wide margin above stall at typical drop speeds and weights, even with a full retardant load.[8]

One drop from the aircraft is equivalent to 12 drops from a Grumman S-2 Tracker.[11] Initially, the aircraft was intended to be operated primarily in California, and the entire state was serviced from the plane's Victorville base at the Southern California Logistics Airport, but in 2007 Cal Fire began looking into setting up a second operations base at Sacramento McClellan Airport in Northern California.[9] 10 Tanker Air Carrier announced in 2007 that a second aircraft would be converted to tanker usage for the 2008 fire season.[9]

 
Inside view of Tanker 910's cockpit

Operational history

edit
 
Flight engineer station

The DC-10s operate with a flight crew of three, a pilot, co-pilot and a flight engineer. The tanker works with a lead plane and can be an effective tool in combating wildfires when working directly with ground resources. 10 Tanker Air Carrier added a second DC-10 (N17085), formerly flown by Continental Airlines, to its fleet in July 2008, to be used on an on-call basis. In late 2014, the company added two additional DC-10s which had previously served with Omni and Northwest Airlines, N612AX and N522AX, which were numbered as Tankers 910 and 912 respectively. The original aircraft, N450AX, was subsequently withdrawn from use in November 2014.

Fire usage

edit

Accepted for use as an air tanker by the US Forest Service (USFS) in 2006, and flying under state and international contracts ever since, the DC-10s were first employed directly by USFS in 2011.[12][13]

In 2006, the aircraft was operated on a limited evaluation contract with the State of California. During the 2006 season, the aircraft was offered on a "call-when-needed" basis, which came with a US$26,500 per-flight-hour (three hour minimum) cost and a 12- to 24-hour activation delay.[6] Under these terms, Tanker 910 flew on six fires in California and one in Washington.[9]

 
Tanker 910 during a drop demonstration in December 2006.

For the 2007–2009 fire seasons, California Governor Arnold Schwarzenegger authorized a contract for exclusive use of the aircraft at a cost of US$5 million per year, or an average of about US$41,000 per day for the June 15 to October 15 fire season; there was an additional US$5,500 per-flight-hour charge.[6] The exclusivity of the contract allowed the aircraft to always be ready for dispatch, and it was able to launch to a fire within one hour of being called.[9][14] In 2011, the exclusive use contract was cancelled by the State of California due to state budgetary constraints.[15]

2006 call-when-needed use

edit

Tanker 910 was first used in July 2006 when it fought the Sawtooth Complex fire in San Bernardino County, California. While the fire was burning, Tanker 910 initially sat on the ground at Victorville, California as it had not received Cal Fire approval to operate. The mayor of Victorville, Mike Rothschild, became concerned and investigated why it was not flying, finding that the approval process was expected to take up to six months to complete. After a call to California State Senator George Runner, Cal Fire was able to complete the necessary training and paperwork in a matter of days, with the California certification being granted on July 15, 2006.[16] The following day, July 16, the aircraft made two drops on the Sawtooth fire, and Cal Fire personnel were reported to have said that "the two fire drops made a greater impact on containing the fire than the 12 helicopters drops for the past 10 days."[16]

Later in the same month, the aircraft was used against several smaller California fires, as well as the Columbia Complex Fire in Washington. In September 2006, Tanker 910 was activated by Cal Fire for use against the Day Fire,[17] and the following month it flew against the Esperanza Fire.[6]

2007 contract use

edit

Under the terms of the exclusive-use contract, Tanker 910 was activated against the 2007 White Fire, where it flew two runs before incurring its incident. After repairs were completed, it was activated for use on the massive Zaca Fire, the second-largest fire in modern California history, in August 2007.[7] Tanker 910 was also activated for the Moonlight Fire in Plumas County in September 2007. On October 22, Tanker 910 became involved in the effort to extinguish several California wildfires, including the Slide Fire and the Grass Fire near Lake Arrowhead. The next activation came on November 24, 2007, when the tanker joined the effort to fight the Corral Fire above Malibu, California.

2008 fires

edit

In June, Governor Arnold Schwarzenegger activated Tanker 910 in response to the state of emergency regarding the Humboldt Fire in Butte County, California, in order to combat the over 20,000-acre (8,100 ha) fire in adverse conditions on rough terrain. It flew sorties out of Sacramento McClellan Airport in Northern California. It made 14 drops, totaling 168,000 U.S. gallons (640,000 L) of retardant, to quell the raging blaze, Hill said. The aircraft also participated in the defense of Big Sur at the end of June and into July.[18]

2009 fires

edit

The aircraft was used during the Station Fire in La Cañada and Acton, California in August 2009.

2009/2010 Australia

edit

On December 19, 2009 Tanker 911[19] arrived in Melbourne, Australia for the Australian fire season. Leased by the National Aerial Firefighting Centre on behalf of the Victoria state government, the DC-10 became operational in Australia in early January 2010, based at Avalon. The Premier of Victoria at the time, John Brumby, described the leasing of the tanker as being part of a record financing program to make sure the state was as fire-ready as possible.[18]

2011 fires

edit

In April 2011,[20] and again in September,[21] the aircraft was deployed to Texas to assist in fighting an outbreak of wildfires. Tanker 910 was expected to assist firefighters in tackling the Bastrop County Complex fire, the most destructive single wildfire in Texas history,[22] but it was not deployed due to delays in preparing the fire-retardant mixing facility at Austin-Bergstrom International Airport.[23]

Tanker 910 was ultimately used to fight a prioritized fire north of Houston, Texas, as the Bastrop County Complex fire had been largely contained by September 16.[24] The aircraft operated from Austin-Bergstrom International Airport, conducting fire-fighting operations across the state. Tanker 910 also made drops last fire season on the Wallow Fire in eastern Arizona, which eventually became the largest wildfire in Arizona history, burning more than 800 square miles (2,100 km2).[25]

2012 fires

edit

2012 was one of the most active fire seasons in United States history. It also marked the first time that Tankers 910 and 911 were deployed simultaneously in the US On August 17, 2012, Tankers 910 and 911 began operations from Sacramento McClellan Airport on numerous fires in California. The total of retardant dropped had exceeded 1.7 million U.S. gallons (6.4 million liters) as of September 8, 2012.[26] The largest fires included the Ponderosa Fire just outside Lassen Volcanic National Park and the Chips Fire in Plumas National Forest near the Lake Almanor Basin.[27] Tanker 911 flew missions on the Taylor Bridge Fire in the Cascade Range, near Cle Elum, Washington, during the 2012 wildfire season.[19]

 
DC-10 tanker in 2013

2013 Exclusive Use Contract

edit

On May 6, 2013, US Forest Service Chief Tom Tidwell announced that the Forest Service had issued a notice of intent to award contracts to five companies to provide a total of seven Next Generation airtankers for wildfire suppression. 10 Tanker Air Carrier was among the five companies selected and one of the companies' DC-10s is contracted for five years with the USFS.[28]

2014

edit
 
DC-10 drops fire retardant on the Mateo Fire at Camp Pendleton, May 16 2014

In addition to the long term exclusive use contract awarded in 2013, the company also received short term contracts for other available aircraft. Tankers 910 and 911 flew extensively on fires in Washington, Oregon and California, and were joined in early September by Tanker 912. 10 Tanker aircraft flew over 325 fire missions in 2014.

2015

edit

All three aircraft flew for the US Forest Service in 2015 and for a short period in Canada, two on call when needed contracts and one on exclusive use. It was a particularly busy fire season in the American West with extensive work in California, Washington and Oregon. In total over 435 missions were flown by the three 10 Tanker aircraft in 2015.

2015/2016 Australia

edit

In late September 2015 Tanker 910 flew from Albuquerque to Australia to begin an exclusive use contract with the State Government of New South Wales. The aircraft was based at RAAF Base Richmond, located 64 km Northwest of Sydney. In the five months Tanker 910 was stationed in Australia, it flew 32 missions in the three Australian states of New South Wales, Victoria and Tasmania. Tanker 910 returned to Albuquerque on February 26, 2016, to begin preparations for the North American fire season.

2016 United States

edit
 
Aerial view of DC-10 Phos-Chek drop on Sherpa Fire June 19, 2016.

In June 2016 a DC-10 Air Tanker was used on The Sherpa, San Gabriel Complex and Pine Fires in Southern California.[29][30][31]

2017 United States

edit

In December 2017 Tanker 911 was seen over the Thomas Fire making multiple drops, based in Santa Maria, California. On December 8, Tanker 911 assisted in mop up operations for the Lilac Fire in Bonsall.

2017/2018 Australia

edit

In November 2017, Tanker 912 was contracted to the New South Wales Rural Fire Service for the summer fire season. It was based at was RAAF Base Richmond and on November 3 was named Nancy Bird after pioneering Australian aviator Nancy Bird Walton.[32]

2019 United States

edit

In October 2019, Tanker 912 was seen at the Kincade fire while Tankers 910, 911 and 914 were used at the Maria fire in southern California.[33]

2019/2020 Australia

edit

During the 2019–20 Australian bushfire season, DC-10 Air Tankers were deployed.[34]

2020 United States

edit
 
DC-10 airtanker dropping a load of retardant on Patantoc Ridge on the Bighorn Fire in 2020

In June 2020, two DC-10 Air Tankers were deployed to the Catalina Foothills in Tucson, Arizona to prevent the Bighorn Fire from reaching the cities of Tucson and Oro Valley. Pilot Dan Montelli praised the tankers for their maneuverability within the steep mountain ridges and inside the tight canyons of the Catalina Foothills. The tankers dumped 9,400 gallons of retardant at a time from a height of 200 to 300 feet above ground level.[35] The tankers successfully prevented the fire from reaching Tucson, as it continued to burn into the Catalina Foothills, and away from the cities.[36]

On August 19, DC-10 Air Tanker Tanker 910 responded to the Copeland Fire, east of McCall, Idaho. On August 23, Tanker 911 responded to the LNU Lightning Complex Fire in Northern California.[37] At the same time, other DC-10 air tankers were deployed to assist with the Pine Gulch Fire burning over 125,000 acres north of Grand Junction, Colorado.[citation needed]

2021/2022 United States

edit
 
Tanker 912 taxiing at Boise International Airport, July 2020
 
Tanker 910 parked at Austin-Bergstrom International Airport, July 2022

On August 14, 2021, a DC-10 Air Tanker was dispatched to a Forest Fire in Utah, known as the Parleys Canyon Wildfire. A DC-10 Air Tanker, along with Utah National Guard Sikorsky UH-60 Black Hawks and other forest fighting aircraft, contained the fire successfully on August 22, 2021.

In May 2022, DC-10 Air Tankers fought the Calf Canyon / Hermit's Peak complex fire west of Las Vegas, NM.[38]

In August 2022, DC-10 Air Tankers fought the Vantage Highway fire east of Ellensburg, WA, as well as the Cow Canyon fire south of Ellensburg.

In September 2022, DC-10 Air Tankers responded to the Mosquito Fire in Foresthill CA.[39]

Incidents

edit

Tanker 910 experienced its first serious aviation incident on June 25, 2007. While on its third run over the White Fire in the Kern County mountains near Tehachapi, California, the aircraft was in a left bank while turning from base to final approach. It encountered sinking air, the left wing dropped, and the aircraft descended 100–200 feet (30–61 m) lower than expected.[14][40] The left wing struck several trees before pilots were able to power out of the descent. The aircraft climbed to altitude for a controllability check and to dump its load of retardant, then returned to its base in Victorville, California where it made an emergency landing and was grounded pending an investigation, inspection, and repairs.[14][40][41]

A post-incident investigation by the US National Transportation Safety Board revealed that the aircraft had suffered damage to the left wing's leading edge slats, ailerons and flaps.[40][42] Despite the incident, Cal Fire stated that they were happy with the aircraft.[43] The aircraft returned to the sky for a test flight after repairs on July 30, 2007.[42][43]

See also

edit

References

edit
  1. ^ "General". 10Tanker.com. Archived from the original on June 8, 2012. Retrieved June 4, 2012.
  2. ^ "HOME". 10TankerAirCarrier. Archived from the original on February 21, 2023.
  3. ^ a b "Supplemental Type Certificate ST01870LA" (PDF). Archived from the original (PDF) on February 4, 2022. Retrieved June 23, 2016.
  4. ^ "Experience". Archived from the original on February 16, 2018. Retrieved July 9, 2013.
  5. ^ "Census data". Jetphotos.net. Retrieved September 11, 2011.
  6. ^ a b c d "DC-10 Airtanker – Tanker 910 Fact Sheet" (PDF). CAL FIRE web site. Archived from the original (PDF) on June 24, 2007. Retrieved August 22, 2007.
  7. ^ a b Daniel, Stacy; Tina Leonard (August 12, 2007). "Critical turn in the Zaca Fire: DC-10 Airtanker flies over and Evacuation Order downgraded". KSBY-TV—San Luis Obispo, CA. MSNBC. Retrieved August 22, 2007.[dead link‍]
  8. ^ a b "The Plane". Archived from the original on February 16, 2018. Retrieved July 9, 2013.
  9. ^ a b c d e "Supertanker ready for summer of fighting California's fires". The Press Enterprise. June 14, 2007. Archived from the original on January 31, 2013. Retrieved July 8, 2009.
  10. ^ "Retired DC-10s Battle Western Blazes". July 8, 2013.
  11. ^ ""DC-10 drops retardant in a first for firefighting" Gizmag, accessed August 10, 2007". Gizmag.com. June 19, 2006. Retrieved September 11, 2011.
  12. ^ "DC-10 lands in Arizona to fight wildfires" Archived June 17, 2012, at the Wayback Machine. AZfamily.com. 12 June 2012. Retrieved 9 December 2012.
  13. ^ US Forest Service (December 12, 2016). "Planes". www.fs.usda.gov. Archived from the original on June 29, 2020. Retrieved September 15, 2020.
  14. ^ a b c Curtis, Bill. "Firefighting jet grounded after grazing trees in Kern County". Fresno Bee. June 26, 2007. Archived September 27, 2007, at the Wayback Machine
  15. ^ Cal Fire Drops DC-10 Air Tanker Contract – Central Coast News KION/KCBA
  16. ^ a b City of Victorville news release Archived September 28, 2007, at the Wayback Machine, "Mayor Rothschild Intervenes in the Sawtooth Fire, Use of DC-10 Tanker Helps Contain the Fire", accessed August 6, 2007
  17. ^ "CAL FIRE News Release, September 24, 2006, accessed August 17, 2007" (PDF). Archived from the original (PDF) on June 24, 2007. Retrieved August 18, 2007.
  18. ^ a b Tanker fleet to add 2nd DC-10 Archived July 15, 2009, at the Wayback Machine Wesley G. Hughes, Staff Writer, Inland Valley Daily Bulletin, Inland Valley, CA. June 22, 2008.
  19. ^ a b "The Week in Pictures". MSNBC. Retrieved 16 October 2012.
  20. ^ "Federal Air Resources Helping Battle Texas Wildfires". Kbtx.com. April 18, 2011. Archived from the original on March 14, 2012. Retrieved September 11, 2011.
  21. ^ "DC-10 to drop retardant starting Friday". KXAN.com. Archived from the original on January 28, 2013. Retrieved September 11, 2011.
  22. ^ Texas fire destroys 1,554 homes, 17 people missing, (Associated Press Archived January 14, 2012, at the Wayback Machine, September 11, 2011)
  23. ^ Fleet of firefighting aircraft to be stationed in Austin, (Austin American Statesman, September 12, 2011) Archived January 20, 2012, at the Wayback Machine
  24. ^ "Fire 80 percent contained in Bastrop" Archived September 24, 2011, at the Wayback Machine. KXAN.com. 16 September 2011. Retrieved 16 March 2013.
  25. ^ "Wallow Fire: DC-10 tanker joins fire fight" Archived August 25, 2013, at the Wayback Machine. AZfamily.com. 9 June 2011. Retrieved 16 June 2013.
  26. ^ Facebook.
  27. ^ Boston.com.
  28. ^ "U.S. Forest Service issues notice of intent to award "Next Generation" airtanker contracts" (Press release). Washington, D.C.: USDA Forest Service. May 6, 2013. Archived from the original on September 2, 2013.
  29. ^ "DC-10 Archives". Fire Aviation. August 6, 2022.
  30. ^ "DC-10 making retardant drops again @ SanGabrielComplex fire".
  31. ^ "Wildfire in los Padres grows rapidly".
  32. ^ "Waterbomber Nancy Bird set for fire season". news.com.au. November 3, 2017. Archived from the original on November 7, 2017. Retrieved November 7, 2017.
  33. ^ "Reagan Library spared from flames as powerful wind gusts drive new wildfire near Los Angeles - The Washington Post". The Washington Post.
  34. ^ "What's Australia doing to fight the bushfires?". January 13, 2020. Retrieved January 14, 2020.
  35. ^ "Battling the Bighorn Fire from above with DC-10 tankers". KGUN. June 19, 2020. Retrieved August 26, 2020.
  36. ^ Rogoway, Tyler (June 13, 2020). "Watch Giant DC-10 Fire Bombers Make Intense Attack Runs On Arizona's Multiple Blazes". The Drive. Retrieved August 26, 2020.
  37. ^ "TNKR911 Flight Tracking and History 21-Aug-2020 (KMCC-KMCC)".
  38. ^ "Calf Canyon and Hermits Peak Fires". May 3, 2022.
  39. ^ "Police Cars, Fire Trucks, & Air Tankers Responding to the Mosquito Fire in Foresthill CA". YouTube. September 7, 2022.
  40. ^ a b c NTSB probable cause report SEA07TA181
  41. ^ MARCUS WOHLSEN – Associated Press (June 27, 2007). "Marcus Wohlsen, "Grounded firefighting jet raised doubts among USFS officials", North County Times, June 26, 2007, accessed August 8, 2007". Nctimes.com. Retrieved September 11, 2011.
  42. ^ a b ""Too Close A Call For Fire-Fighting DC-10?", KTVU-TV, August 6, 2007, accessed August 10, 2007". Ktvu.com. August 6, 2007. Archived from the original on September 27, 2011. Retrieved September 11, 2011.
  43. ^ a b O'Driscoll, Patrick (July 18, 2007). "Patrick O'Driscoll, "Use of jets to fight fires up in air", USA Today, July 17, 2007". Usatoday.com. Retrieved September 11, 2011.
edit
 
Wikimedia Commons has media related to McDonnell Douglas DC-10 waterbomber.
Retrieved from "https://en.wikipedia.org/w/index.php?title=DC-10_Air_Tanker&oldid=1256485349"