The Rubber Bandit was an experimental aircraft, designed and built in the 1990s by George Heaven, of Van Nuys, California, which was powered by a rubber-band motor.
Heaven Rubber Bandit | |
---|---|
![]() | |
First rollout of the Rubber Bandit | |
Role | Experimental aircraft |
National origin | United States |
Manufacturer | George Heaven |
Number built | 1 |
Development
editGeorge Heaven was a pilot and aeronautical engineer who wanted to make the first flight in a rubber powered airplane.[1] Development work included the building and testing of a 1⁄25th scale free flight model, which had a 27 in (69 cm) wingspan. This was followed by building and testing of a 1⁄4 scale rubber powered, radio-controlled model, which had a 17 ft (5.2 m) wingspan. The latter craft was said to be the largest rubber-powered airplane to have taken off and flown under its own power.[2]
The full-sized craft, dubbed the Rubber Bandit, was of conventional configuration. It was a high-wing monoplane, fitted with a tractor propeller. The craft's primary structure was made of carbon-fiber and Kevlar tubing, with the wings and tail surfaces being built from carbon-fiber ribs, and covered in blue Mylar film.[3] The wing was of constant chord, with the outer panels set at a slight dihedral. There were no ailerons, with all control being via the tail surfaces, which were operated by remote control servos. The fuselage consisted of a single tube, within which the rubber-motor was contained. A small nacelle, located under the fuselage and below the wing, accommodated the pilot and a passenger.[4]
Rubber motor
editThe motor was made of 0.25 in (0.64 cm)-wide rubber, folded into 800 strands, and measured 20 ft (6.1 m) long and would be wound up to 800 revolutions. The motor is lubricated with 3 gallons of castor oil.[1] According to an article in Flying the motor, fully wound, would initially generate the equivalent of 11 hp (8.2 kW), at high torque and rpm, before reducing down to 4 hp (3.0 kW) after 20 seconds.[3] The motor would run for an estimated 90 seconds, sufficient for the airplane to take off and make a 0.5 mi (0.80 km) flight.
Testing
editInitial media coverage indicated the airplane would be completed and flight testing undertaken before the end of 1996.[2][1] A 1998 Los Angeles Times article reported that the first taxi tests took place in March 1998, with the second being on May 3.[4] A 2011 article published on the Sustainable Skies website reported that testing of the Rubber Bandit had continued through to 2003, with some short hops but no flights being made.[5]
Specifications
editData from George Heaven[6]
General characteristics
- Crew: 1 pilot 175 lb (79.38 kg)
- Capacity: 1 passenger 100 lb (45.36 kg)
- Length: 33 ft (10 m)
- Wingspan: 76 ft (23 m)
- Wing area: 338 sq ft (31.4 m2)
- Aspect ratio: 17.08
- Airfoil: NACA laminar flow, 15% thickness
- Empty weight: 250 lb (113 kg) not including rubber motor
- Gross weight: 615 lb (279 kg)
- Powerplant: 1 × 90 lb rubber motor 20 ft long, 11 hp (8.2 kW)
- Propellers: 2-bladed, 18 ft 2 in (5.54 m) diameter ground adjustable pitch
Performance
- Maximum speed: 55 mph (89 km/h, 48 kn)
- Cruise speed: 32 mph (51 km/h, 28 kn)
- Stall speed: 20 mph (32 km/h, 17 kn)
- Range: 1.0 mi (1.6 km, 0.87 nmi)
- Endurance: 2 minutes
- Wing loading: 1.82 lb/sq ft (8.9 kg/m2)
See also
edit
References
edit- ^ a b c Barry, Dave (2000). "Rubber-Band Man". Dave Barry is not taking this sitting down!. New York, NY: Crown Publishers. pp. 11–13. ISBN 0609600672. Retrieved May 28, 2023.
- ^ a b Carter, Peter (March 1999). "The Rubber Bandit Project" (PDF). New Clarion SAM 1066 Newsletter. No. 32019. Rugby, UK: Society of Antique Modellers. p. 15. Retrieved May 28, 2023.
- ^ a b Garrison, Peter (February 1996). "Rubber power stretches a new design". Flying. Vol. 123, no. 2. New York, NY: Hachette Filipacchi Magazines, Inc. pp. 98–99. ISSN 0015-4806. Retrieved May 28, 2023.
- ^ a b Willman, Martha L. (May 11, 1998). "Experimental Aircraft Expected to Stretch the Limits of Aviation". Los Angeles Times. Retrieved May 28, 2023.
- ^ Sigler, Dean (August 9, 2011). "A Chance to Unwind". Sustainable Skies. Retrieved May 28, 2023.
- ^ "Aircraft Technical Data". www.rubberbandit.org. Rubber Bandit. Archived from the original on February 5, 2005. Retrieved May 29, 2023.